|British Rail Class 221 Super Voyager|
|In service||12 April 2002–present|
|Number built||44 sets|
|Number in service||44 sets|
|Formation||4 or 5 cars per set|
|Capacity||26 first class, 162 or 224 standard class per unit|
|Operator(s)||Avanti West Coast|
|Car body construction||Steel|
|Car length||23.85 m (78 ft 3 in) driving end cars|
22.82 m (74 ft 10 in) other cars
|Width||2.73 m (8 ft 11 in)|
|Doors||Swing plug at vehicle ends|
|Articulated sections||Flexible diaphragm within unit only|
|Maximum speed||125 mph (200 km/h)|
|Weight||227 t (223 long tons; 250 short tons) or 282.8 t (278.3 long tons; 311.7 short tons) per 4 car unit|
|Prime mover(s)||One per car, Cummins QSK19 19-litre 6-cylinder turbo-Diesel|
|Power output||560 kW (750 hp) per car at 1800rpm|
|Braking system(s)||Rheostatic and electro-pneumatic|
|Safety system(s)||AWS, TPWS, TASS|
The British Rail Class 221 Super Voyager is a class of tilting diesel-electric multiple-unit express passenger trains built in Bruges, Belgium, by Bombardier Transportation in 2001/02.
The Class 221 are similar to the Class 220 Voyager units, but were built with a tilting mechanism enabling up to six degrees of tilt to allow higher speeds on curved tracks, most have five coaches, and they have a different bogie design. They have a maximum speed of 125 mph (200 km/h).
Currently these trains are divided between two operators, Avanti West Coast (20 sets) and CrossCountry (24 sets). The sets operated by CrossCountry had their tilt function disabled in 2008 to improve reliability and reduce maintenance costs.
The Class 221s were produced as 5- or 4-coach sets. Each coach is equipped with a Cummins QSK19 diesel engine producing 560 kW (750 hp) at 1,800 rpm, driving an electrical generator which powers two motors, each driving one (inner) axle per bogie via a cardan shaft and final drive. 1,200 miles (1,900 km) can be travelled between refuellings. The coach bodies, the engines and most of the equipment of the Class 221s are the same as the Class 220s, but the bogies are very different: the Class 220 Voyager B5000 bogies have inside-frames which expose the whole of the wheel faces, while the Class 221 SuperVoyager Y36 bogies have a more traditional outside-framed bogie. Unlike the Class 220s, the Class 221s were built with a hydraulic-actuated tilting system to run at high speed around bends, though this has now been disabled from the 23 sets operated by CrossCountry.
Each coach weighs between 55 and 57 tonnes, with a total train weight of 281.9 tonnes for a 5-car set (227 tonnes for a 4-car set). The trains have air-operated (pneumatic) and rheostatic brakes, with an emergency stopping distance of 350m at 60 mph (97 km/h).
Class 221 units are fitted with automatic sanding systems. The Avanti West Coast operated units are fitted with a Vossloh fixed rate sander and the Arriva Cross Country operated units are fitted with AB Hoses and fittings variable rate sanding system.
All Class 221 units are maintained at the dedicated Central Rivers TMD near Burton-on-Trent.
As part of a franchise commitment to replace all of the Mark 2 and High Speed Train sets, Virgin CrossCountry ordered 40 five-carriage sets. In addition four four-carriage sets were ordered to replace High Speed Trains on Virgin Trains' North Wales Coast Line services to Holyhead. However all entered service with Virgin CrossCountry.
In November 2010, Virgin Trains reformed its three four-car sets into two five-car sets and a residual spare two-car set by inserting the two intermediate (non-driving) cars from 221144 into 221142 and 221143, giving 20 five-car sets (and two spare driving cars). This was aimed at providing more flexibility and consistency in operating Birmingham-Scotland and London-North Wales services. In 2017 a further reformation took place, allowing 221144 to be returned to traffic with CrossCountry, now operated by Arriva, involving the exchange of some vehicles between Virgin and CrossCountry and the reduction of two CrossCountry sets to four car formations.
All vehicles are air-conditioned and fitted with Wifi provided by T-Mobile. On some units, the at-seat audio entertainment system is still present however it has now been disabled since the WiFi hot spots were introduced. Power sockets are also available for laptop computers and mobile-phone charging. First-class accommodation has 2+1 seating, standard class 2+2 seating. Virgin Trains' units are fitted with CCTV. These trains, unlike the older trains they replaced, have electronic information display boards in the exterior walls showing the train number, the time, the coach, the train's destination and the next station. This is also a feature of the Class 220 and Class 222 high speed DEMUs (The Class 390 trains also have such electronic information display boards, but in the doors).
The trains have been criticised for providing insufficient space for luggage and bicycles. Also, because the units are designed to tilt, the carriages have a tapered profile that narrows towards roof level, resulting in a less spacious interior than the conventional carriages they replaced.
The formation and capacity of each unit depends on the operator.
|Operator||Cars per set||First Class Seats||Standard Class Seats||Wheelchair spaces||Bicycle storage||Formation|
|Avanti West Coast||5||26||230||2||4||Coach A Quiet Zone, Coach D Shop, Coach E First Class.|
|CrossCountry||26||236||2||3||Coach A First Class, Coach D bicycle rack and luggage storage, at seat catering service.|
|CrossCountry||4||26||174||2||3||Coach A First Class, Coach D bicycle rack and luggage storage, at seat catering service.|
All units are owned by Beacon Rail, after they were purchased from Voyager Rail Leasing, a consortium of Lloyds Banking Group and Angel Trains. They are leased to the train operating companies.
On their introduction in 2002, Virgin Trains was the operator of all Class 221s, which it used on CrossCountry and West Coast Main Line services as well as on the North Wales Coast line.
With the decision to transfer those CrossCountry services that operated via the West Coast Main Line to the InterCity West Coast franchise at the same time as the former franchise was relet, on 11 November 2007 the fleet was split. Virgin West Coast were allocated 221101-221118 and 221142-221144 while CrossCountry gained 221119-221141. However while CrossCountry overhauled five High Speed Train sets, 221114-221118 were subleased for a 12-month period.
CrossCountry's Class 221s operate alongside 220s on the routes inherited from Virgin CrossCountry. Since these routes are not cleared for tilting operation (with the exception of Wolverhampton to Stockport), in 2008 the tilting equipment was locked out of use and shortly afterwards was isolated altogether, replacing the hydraulic rams with fixed tie-bars. This change was made to improve reliability and reduce maintenance costs.
Avanti West Coast uses the Class 221 units primarily from London Euston to Scotland via Birmingham New Street (despite the route being electrified throughout) and, from London Euston to Shrewsbury and, London Euston to Chester and North Wales. They are also used by a few London Euston to West Midlands services.
The trains to and from Scotland often operate as double units and alternate between Glasgow Central and Edinburgh Waverley (in turn alternating with TransPennine Express trains to and from Manchester Airport). When longer trains are needed for some of the busier services, a Pendolino will run through from and to London Euston, and the Super Voyager then fills in for it on the London to West Midlands route.
The trains on the North Wales route sometimes operate as double units. They run from London Euston and Chester and terminate at any of Chester, Holyhead, Bangor or Wrexham.
Units have been stopped due to waves breaking over the sea wall at Dawlish in storm conditions, inundating the resistor banks and causing the control software to shut down the whole train. This problem was fixed by a software upgrade to the control software.
On 8 December 2005, 221125 suffered an exhaust fire at Starcross. Other members of the Voyager class suffered similar fires in the 2005-2006 period due to an incorrectly performed engine overhaul.
On 25 September 2006, 221136 collided with a car on the track at Moor Lane, Copmanthorpe, North Yorkshire. The 14:25 Plymouth to Edinburgh was decelerating on its approach to York station at 9pm when it collided with the car, which had crashed through a fence on to the line. Despite being derailed in the 100-mile-per-hour (160 km/h) crash, the train remained upright. Nobody on board was injured.
On 4 July 2009, 221112 was involved in a collision between with a set of freight train container doors, Eden Valley Loop, Penrith. At 16:27, Virgin Trains (1M86) service from Edinburgh to Birmingham New Street passed service 4M16, a container freight train which was in the Eden Valley Loop. The train struck one or both open doors of wagons 12 and or 13 of the container train. The crew of the service heard the impacts and stopped to report the damage to their control at 16:28. The train suffered damage to all cars consisting of scratching to bodywork, in particular doors, as well as severe damage to one door step. The Super Voyager was one of three trains to be damaged by the container doors; a Class 390 and a Class 185 were also involved.
On 20 November 2013 a Virgin Super Voyager (221105) overran the platform and ran into the buffers at Chester. One passenger was taken to hospital. The RAIB report concluded that this was due to exceptionally low adhesion between wheels and rails, combined with train's sanding system being inadequate. The report recommended that the sanding equipment on the class be upgraded.
The Virgin-operated Class 221 Super Voyagers were originally referred to by Bombardier as the Virgin Explorer class as they were to be named after famous explorers, some fictional, mostly real, as follows:
|221101||101 Squadron||Avanti West Coast||formerly Louis Blériot|
|221102||formerly John Cabot|
|221103||formerly Christopher Columbus|
|221104||formerly Sir John Franklin|
|221105||formerly William Baffin|
|221106||formerly Willem Barents. Wore a branded livery to promote Festival No. 6 music event in Portmeirion, North Wales|
|221107||formerly Sir Martin Frobisher|
|221108||formerly Sir Ernest Shackleton|
|221109||formerly Marco Polo|
|221110||formerly James Cook|
|221111||formerly Roald Amundsen|
|221112||formerly Ferdinand Magellan|
|221113||formerly Sir Walter Raleigh|
|221114||formerly Royal Air Force Centenary 1918-2018 and Sir Francis Drake|
|221115||formerly Polmadie Depot and Sir Francis Chichester. Wore a unique co-branded livery in partnership with Bombardier and Virgin Trains from September 2010 until January 2021. First set to gain the hybrid Avanti West Coast livery.|
|221116||City of Bangor / Dinas Bangor||Formerly David Livingstone. Wears a different nameplate on each side, one in English and the other in Welsh.|
|221117||formerly The Wrekin Giant and Sir Henry Morton Stanley|
|221118||formerly Mungo Park|
|221119||CrossCountry||formerly Amelia Earhart|
|221120||formerly Amy Johnson|
|221121||formerly Charles Darwin|
|221122||formerly Doctor Who|
|221123||formerly Henry Hudson|
|221124||formerly Charles Lindbergh|
|221125||formerly Henry the Navigator|
|221126||formerly Captain Robert Scott|
|221127||formerly Wright Brothers|
|221128||formerly Captain John Smith|
|221129||formerly George Vancouver|
|221130||formerly Michael Palin|
|221131||formerly Edgar Evans|
|221132||formerly William Speirs Bruce|
|221133||formerly Alexander Selkirk|
|221134||formerly Mary Kingsley|
|221135||formerly Donald Campbell|
|221136||formerly Yuri Gagarin. This was originally a 5 coach unit, but was converted to 4 coaches.|
|221137||formerly Mayflower Pilgrims|
|221138||formerly Thor Heyerdahl|
|221139||formerly Leif Eriksson|
|221140||formerly Vasco Da Gama. This was originally a 5 coach unit, but was converted to 4 coaches.|
|221141||formerly Amerigo Vespucci. This is a 4 coach unit.|
|221142||Avanti West Coast||formerly Bombardier Voyager and Matthew Flinders. This was originally a 4 coach unit, but was converted to 5 coaches.|
|221143||formerly Auguste Picard. This was originally a 4 coach unit, but was converted to 5 coaches.|
|221144||CrossCountry||formerly Prince Madoc. This is a 4 coach unit.|
In December 2019, Avanti West Coast placed an order for 10 seven-car electric units which will replace its Class 221 fleet, along with 13 Class 805 bi-mode units as part of £350 million contract with Hitachi. All are scheduled to be in service by 2022.
|Class||Operator||Number||Built||Cars per Set||Unit numbers|
|Class 221||Avanti West Coast||20||2001–02||5||221101–118, 221142–143|
|4||4||221136, 221140–141, 221144|
In 2014, CrossCountry set 220007 suffered a fire seriously damaging coach C. As a quick fix, CrossCountry decided to remove a coach from unit 221135, and place this vehicle within 220007. There is a noticeable difference between the vehicles due to the different sort of bogies used on Class 220 and Class 221 units. In February 2015 both 220007 and 221135 were returned to their original formations.
216 SuperVoyager cars capable of tilting 6° ... will use the well-proven Y36 bogie with hydraulic tilt actuation.
Drive configuration [diagram][permanent dead link]
Virgin Trains is no longer operating any Class 221 Super Voyager trains as four-car units.