|Part of a series on|
|List of space organizations|
A reusable launch system is a launch system that allows for the reuse of some or all of the component stages. To date, several fully reusable suborbital systems and partially reusable orbital systems have been flown.
The first reusable spacecraft to reach orbit was the Space Shuttle (in 1981), which failed to accomplish the intended goal of reducing launch costs to below those of expendable launch systems.
During the 21st century, commercial interest in reusable launch systems has grown considerably, with several active launchers. SpaceX CEO Elon Musk has said that if one can figure out how to reuse rockets like airplanes then the cost of access to space will be reduced by as much as a factor of a hundred. SpaceX's Falcon 9 rocket has a reusable first stage and capsule (for Dragon flights) with an expendable second stage. SpaceX has been developing a reusable second stage since the late 2010s which, if successful, could make possible the first fully-reusable orbital launch vehicle during the 2020s. Virgin Galactic has flown reusable suborbital spaceplanes, and the suborbital Blue Origin New Shepard rocket has a recoverable boost stage and passenger capsule.
Reusable launch systems may be either fully- or partially-reusable.
As of August 2021[update], fully-reusable orbital systems have yet to be built and made operational. Fully-reusable launch vehicles could theoretically be single-stage-to-orbit (SSTO) vehicles, as well as multi-stage-to orbit systems.
Three companies are currently in development to achieve fully-reusable launch vehicles as of July 2021. Each of them is working on a two-stage-to-orbit system. SpaceX, with their SpaceX Starship, has been in development since 2016 and is aiming to make an initial test flight of a part of the system capabilities as early as 2022. Relativity Space, with their Terran R beginning development by 2021, is aiming to make an initial orbital launch test by 2024. Blue Origin, with Project Jarvis, began development work by early 2021, but has announced no date for testing, nor even been public with their plans.
Earlier plans to run tests of enhanced reusability on the second stage of the SpaceX Falcon 9 were set aside in 2018.
Partial reusable launch systems, in the form of multiple stage to orbit systems have been so far the only reusable configurations in use.
Existing reusable launch systems use rocket-propelled vertical liftoff.[needs update]
Other than that a range of non-rocket liftoff systems have been proposed and explored over time as reusable systems for liftoff, from balloons[relevance questioned] to space elevators. Existing examples are systems which employ winged horizontal jet-engine powered liftoff. Such aircraft can air launch expendable rockets and can because of that be considered partially reusable systems if the aircraft is thought of as the first stage of the launch vehicle. An example of this configuration is the Orbital Sciences Pegasus. For suborbital flight the SpaceShipTwo uses for liftoff a carrier plane, its mothership the Scaled Composites White Knight Two.
So far, launch systems achieve orbital insertion with multistaged rockets, particularly with the second and third stages. Only the Space Shuttle has achieved a partial reuse of the orbital insertion stage, by using the engines of its orbiter.
Main article: Reusable spacecraft
Launch systems can be combined with reusable orbiters. The Space Shuttle orbiter, SpaceShipTwo and the under-development Indian RLV-TD are examples for a reusable space vehicle (a spaceplane) as well as a part of its launch system.
More contemporarily the Falcon 9 launch system has carried reusable vehicles such as the Dragon 2 and X-37, transporting two reusable vehicles at the same time.
Contemporary reusable orbital vehicles include the X-37, the Dream Chaser, the Dragon 2, the Indian RLV-TD and the upcoming European Space Rider (successor to the IXV).
As with launch vehicles, all pure spacecraft during the early decades of human capacity to achieve spaceflight were designed to be single-use items. This was true both for satellites and space probes intended to be left in space for a long time, as well as any object designed to return to Earth such as human-carrying space capsules or the sample return canisters of space matter collection missions like Stardust (1999–2006) or Hayabusa (2005–2010). Exceptions to the general rule for space vehicles were the US Gemini SC-2, the Soviet Union spacecraft Vozvraschaemyi Apparat (VA), the US Space Shuttle orbiter (mid-1970s-2011, with 135 flights between 1981 and 2011) and the Soviet Buran (1980-1988, with just one uncrewed test flight in 1988). Both of these spaceships were also an integral part of the launch system (providing launch acceleration) as well as operating as medium-duration spaceships in space. This began to change in the mid-2010s.
In the 2010s, the space transport cargo capsule from one of the suppliers resupplying the International Space Station was designed for reuse, and after 2017, NASA began to allow the reuse of the SpaceX Dragon cargo spacecraft on these NASA-contracted transport routes. This was the beginning of design and operation of a reusable space vehicle.
Since then also the Boeing Starliner capsules reduce their fall speed with parachutes and deploy an airbag shortly before touchdown on the ground, in order to retrieve and reuse the vehicle.
As of 2021[update], SpaceX is currently building and testing the Starship spaceship to be capable of surviving multiple hypersonic reentries through the atmosphere so that they become truly reusable long-duration spaceships; no Starship operational flights have yet occurred.
Main article: Atmospheric entry
With possible inflatable heat shields, as developed by the US (Low Earth Orbit Flight Test Inflatable Decelerator - LOFTID) and China, single-use rockets like the Space Launch System are considered to be retrofitted with such heat shields to salvage the expensive engines, possibly reducing the costs of launches significantly.
Launch systems like the Falcon 9 employ for their reusable stages not only at landing retrograde burns, but also at re-entry and even for boostback burns, to return home, instead of only aiming for landing downrange.
Reusable systems can come in single or multiple (two or three) stages to orbit configurations. For some or all stages the following landing system types can be employed.
See also: Water landing
These are landing systems that employ parachutes and bolstered hard landings, like in a splashdown at sea or a touchdown at land.
Though such systems have been in use since the beginning of astronautics to recover space vehicles, particularly crewed space capsules, only later have the vehicles been reused.
Main article: Spaceplane
Single or main stages, as well as fly-back boosters can employ a horizontal landing system.
A variant is an in-air-capture tow back system, advocated by a company called EMBENTION with its FALCon project.
Vehicles that land horizontally on a runway require wings and undercarriage. These typically consume about 9-12% of the landing vehicle mass, which either reduces the payload or increases the size of the vehicle. Concepts such as lifting bodies offer some reduction in wing mass, as does the delta wing shape of the Space Shuttle.
Systems like the McDonnell Douglas DC-X (Delta Clipper) and those by SpaceX are examples of a retrograde system. The boosters of Falcon 9 and Falcon Heavy land using one of their nine engines. The Falcon 9 rocket is the first orbital rocket to vertically land its first stage on the ground. Both stages of Starship are planned to land vertically.
Retrograde landing typically requires about 10% of the total first stage propellant, reducing the payload that can be carried due to the rocket equation.
There is also the concept of a launch vehicle with an inflatable, reusable first stage. The shape of this structure will be supported by excess internal pressure (using light gases). It is assumed that the bulk density of the first stage (without propellant) is less than the bulk density of air. Upon returning from flight, such a first stage remains floating in the air (without touching the surface of the Earth). This will ensure that the first stage is retained for reuse. Increasing the size of the first stage increases aerodynamic losses. This results in a slight decrease in payload. This reduction in payload is compensated for by the reuse of the first stage. 
Reusable stages weigh more than equivalent expendable stages. This is unavoidable due to the supplementary systems, landing gear and/or surplus propellant needed to land a stage. The actual mass penalty depends on the vehicle and the return mode chosen.
After the launcher lands, it may need to be refurbished to prepare it for its next flight. This process may be lengthy and expensive. The launcher may not be able to be recertified as human-rated after refurbishment, although SpaceX has flown reused Falcon 9 boosters for human missions. There is eventually a limit on how many times a launcher can be refurbished before it has to be retired, but how often a spacecraft can be reused differs significantly between the various launch system designs.
With the development of rocket propulsion in the first half of the twentieth century, space travel became a technical possibility.
Early ideas of a single-stage reusable spaceplane proved unrealistic and although even the first practical rocket vehicles (V-2) could reach the fringes of space, reusable technology was too heavy. In addition many early rockets were developed to deliver weapons, making reuse impossible by design. The problem of mass efficiency was overcome by using multiple expendable stages in a vertical-launch multistage rocket. USAF and NACA had been studying orbital reusable spaceplanes since 1958, e.g. Dyna-Soar, but the first reusable stages did not fly until the advent of the US Space Shuttle in 1981.
Perhaps the first reusable launch vehicles were the ones conceptualized and studied by Wernher von Braun from 1948 until 1956. The Von Braun Ferry Rocket underwent two revisions: once in 1952 and again in 1956. They would have landed using parachutes.
The General Dynamics Nexus was proposed in the 1960s as a fully reusable successor to the Saturn V rocket, having the capacity of transporting up to 450–910 t (990,000–2,000,000 lb) to orbit. See also Sea Dragon, and Douglas SASSTO.
The BAC Mustard was studied starting in 1964. It would have comprised three identical spaceplanes strapped together and arranged in two stages. During ascent the two outer spaceplanes, which formed the first stage, would detach and glide back individually to earth. It was canceled after the last study of the design in 1967 due to a lack of funds for development.
NASA started the Space Shuttle design process in 1968, with the vision of creating a fully reusable spaceplane using a crewed fly-back booster. This concept proved expensive and complex, therefore the design was scaled back to reusable solid rocket boosters and an expendable external tank. Space Shuttle Columbia launched and landed 27 times and was lost with all crew on the 28th landing attempt; Challenger launched and landed 9 times and was lost with all crew on the 10th launch attempt; Discovery launched and landed 39 times; Atlantis launched and landed 33 times.
In 1986 President Ronald Reagan called for an air-breathing scramjet National Aerospace Plane (NASP)/X-30. The project failed due to technical issues and was canceled in 1993.
In the late 1980s a fully reusable version of the Energia rocket, the Energia II, was proposed. Its boosters and core would have had the capability of landing separately on a runway.
In the 1990s the McDonnell Douglas Delta Clipper VTOL SSTO proposal progressed to the testing phase. The DC-X prototype demonstrated rapid turnaround time and automatic computer control.
In mid-1990s, British research evolved an earlier HOTOL design into the far more promising Skylon design, which remains in development.
From the late 1990s to the 2000s, the European Space Agency studied the recovery of the Ariane 5 solid rocket boosters. The last recovery attempt took place in 2009.
The commercial ventures, Rocketplane Kistler and Rotary Rocket, attempted to build reusable privately developed rockets before going bankrupt.
NASA proposed reusable concepts to replace the Shuttle technology, to be demonstrated under the X-33 and X-34 programs, which were both cancelled in the early 2000s due to rising costs and technical issues.
The Ansari X Prize contest was intended to develop private suborbital reusable vehicles. Many private companies competed, with the winner, Scaled Composites, reaching the Kármán line twice in a two-week period with their reusable SpaceShipOne.
In 2012, SpaceX started a flight test program with experimental vehicles. These subsequently led to the development of the Falcon 9 reusable rocket launcher.
On 23 November 2015 the New Shepard rocket became the first Vertical Take-off, Vertical Landing (VTVL) sub-orbital rocket to reach space by passing the Kármán line (100 km or 62 mi), reaching 329,839 ft (100,535 m) before returning for a propulsive landing.
SpaceX achieved the first vertical soft landing of a reusable orbital rocket stage on December 21, 2015, after delivering 11 Orbcomm OG-2 commercial satellites into low Earth orbit.
The first reuse of a Falcon 9 first stage occurred on 30 March 2017. SpaceX now semi-routinely recovers and reuses their first stages, as well as reusing fairings.
In 2019 Rocket Lab announced plans to recover and reuse the first stage of their Electron launch vehicle, intending to use parachutes and mid-air retrieval. On 20 November 2020, Rocket Lab successfully returned an Electron first stage from an orbital launch, the stage softly splashing down in the Pacific Ocean.
China is researching the reusability of the Long March 8 system.
As of May 2020[update], the only operational reusable orbital-class launch systems are the Falcon 9 and Falcon Heavy, the latter of which is based upon the Falcon 9. SpaceX is also developing the fully-reusable Starship launch system, and Blue Origin is developing its own New Glenn partially-reusable orbital rocket, as it is intending to recover and reuse only the first stage.
5 October 2020, Roscosmos signed a development contract for Amur a new launcher with a reusable first stage.
In December 2020, ESA signed contracts to start developing THEMIS, a prototype reusable first stage launcher.
|SpaceX||Falcon 9||US||Orbital||Operational||95||77||First stage and fairing reusable.|
|SpaceX||Falcon Heavy||US||Orbital||Operational||?||?||First stage core, side boosters and fairing reusable.|
|SpaceX||Starship||US||Orbital||Under development||0||0||Fully reusable.|
|Rocket Lab||Electron||New Zealand||Orbital||Operational||3||0||First stage recovered but not yet reused.|
|Rocket Lab||Neutron||New Zealand||Orbital||Under development||First stage and fairing reusable|
|Blue Origin||New Shepard||US||Suborbital||Operational||19||?||Fully reusable|
|Blue Origin||New Glenn||US||Orbital||Under development||First stage reusable|
|Virgin Galactic||SpaceShipTwo (VSS Unity)||US||Suborbital||Operational||5||4||Designed for space tourism. Fully reusable|
|Virgin Galactic||SpaceShipThree (VSS Imagine)||US||Suborbital||Prototype||Designed for space tourism. Fully reusable|
|United Launch Alliance||Vulcan Centaur||US||Orbital||Under development||First stage engine module reusable in a later development.|
|NASA||Space Shuttle||US||Orbital||Retired||133||130||Orbiter and side boosters reusable|
|NPO-Energia||Energia-Buran or OK-GLI||USSR||Orbital||Retired||1||0||Only Buran orbiter payload reusable; Energia launcher fully expended.|
|ISRO||RLV TSTO||India||Orbital||Under development||Two Stage to Orbit with initial upper stage reusability and eventual full reusability|
|PLD Space||Miura 5||Spain||Orbital||Under development||First stage reusable.|
|Galactic Energy||Pallas-1||China||Orbital||Under development||Prototype, planned to feature vertical first stage recovery|
|China Academy of Launch Vehicle Technology||Long March 8||China||Orbital||Under development||First stage and attached boosters reusable|
|ESA||Themis||EU||Orbital||Under development||Prototype, aiming for first stage reuse|
|Relativity Space||Terran R||US||Orbital||Under development||First fully reusable 3D printed rocket|
((cite AV media)): CS1 maint: location (link)