TransAsia Airways Flight 235 was a domestic flight from Taipei to Kinmen, Taiwan. On 4 February 2015, the aircraft serving the flight, a 10-month-old ATR 72-600, crashed into the Keelung River around 5 km (3.1 mi; 2.7 nmi) from Taipei Songshan Airport, where the aircraft had just departed from. On board were 58 people, 15 of whom survived.
Two minutes after takeoff, the pilots reported an engine failure. After climbing to a maximum height of 1,630 ft (500 m), the other engine, still operating normally, was mistakenly shut down.[1][2] The aircraft lost altitude, banked sharply to the left and clipped a taxi travelling west on the Huandong Viaduct (causing two more injuries), then the viaduct itself, before crashing into the river below.
Flight 235 was the second fatal accident involving a TransAsia Airways ATR aircraft within seven months; Flight 222 had crashed on 23 July 2014, killing 48 of the 58 onboard.
Flight
Kinmen Airport
Taipei Songshan Airport
Location of the accident and departure/destination airports
Flight 235 departed Taipei Songshan Airport at 10:52Taiwan time(02:52 UTC), for its destination of Kinmen Airport, with 53 passengers and five crew members on board.[3] Shortly after take-off, a fault in the autofeather unit of the number-2 engine caused the automatic take-off power control system to autofeather that engine.[4]: 146 [a] The flight crew misdiagnosed the problem, and shut down the still-functioning number-1 engine.[4]: 146 The aircraft reached an altitude of 1,630 ft (500 m) and then began descending until it crashed.[4]: 3 [5] The last pilot communication to air traffic control was: "Mayday, mayday, engine flameout."[6][7] At 10:55,[4]: 4 the aircraft crashed into the Keelung River, on the border of Nangang District of Taipei and Xizhi District of New Taipei.
The crash was recorded by dashcams in several cars travelling west along the elevated Huandong Viaduct next to the river. The aircraft, flying level, first cleared an apartment building. Then it rolled sharply, at nearly a 90° bank angle, left wing down. As the aircraft flew low over the elevated viaduct, its left wingtip struck the front of a Volkswagen Caddy taxi travelling west on the viaduct, and the outboard section of the wing was torn off when it struck the concrete guardrail at the edge of the viaduct.[7][8] The aircraft continued its roll and struck the water upside down,[9] breaking into two main pieces.[10] The collision with the taxi and the viaduct was captured in footage from a dashcam in a car travelling a short distance behind the taxi, and debris from the plane's wing and pieces of the viaduct's guardrail were thrown across the road surface.[11] Two people in the taxi suffered minor injuries.[6][8][12]
At the time of the accident, no adverse weather phenomena were observed. At 11:00, the cloud base at Songshan was about 1,500 ft (460 m), the visibility was unrestricted, and a light breeze was blowing from the east at 10 knots (19 km/h; 12 mph). The temperature was 16 °C (61 °F).[5]
Aircraft
B-22816, the ATR-72 involved, photographed in January 2015
The passenger manifest was composed of 49 adults and 4 children. Thirty-one passengers were mainland Chinese; many were visitors from Xiamen on a six-day tour of Taiwan.[14][15] The remaining 22 passengers were Taiwanese.[7]
The flight crew consisted of two pilots, both ranked as captains; the captain was Liao Chien-tsung, 42, with a total of 4,914 flight hours (including 250 hours on the ATR 72) and the co-pilot was Liu Tze-chung, 45, with a total of 6,922 flight hours, including 5,314 hours on the ATR 72.[5][15][16] Also, an observer, Hung Ping-chung, 63, was seated in the cockpit jump seat, who had a total of 16,121 flight hours, 6,482 of them on the ATR 72.[17] Two flight attendants were working as cabin crew. All crew members were Taiwanese citizens; the co-pilot was a dual New Zealand–Taiwanese citizen.[16]
Rescue operations in the Keelung River around the wreckage of Flight 235, the Huandong Viaduct in the background
Taipei police and fire departments received dozens of calls from eyewitnesses almost immediately after the crash. The Taipei Fire Department, military, and volunteer rescue workers arrived at the crash scene within minutes,[4]: 49 and reached the survivors by boat around 35 minutes after the crash.[4]: 45 They began removing survivors from the rear section of the semisubmerged fuselage and ferried them to shore in inflatable boats. Divers were forced to cut the seat belts of dead passengers, located mostly in the front section, to remove their bodies. That work was made difficult by low visibility under water.[4]: 48–50
The aircraft's flight recorders were recovered shortly after 16:00 that day. After 20:00, cranes were used to lift large sections of the fuselage ashore.[6][18][19]
Of the 58 people on board the flight, only 15 survived.[20] One of the two flight attendants, Huang Ching-ya, survived.[21]
Press reports
Some media outlets reported anonymous claims that the pilot had complained of "engine abnormalities" and asked for an inspection of the aircraft prior to take-off, but that the request had been refused.[22] This assertion has been denied by both TransAsia Airways and the Civil Aeronautics Administration, the former of whom has released the maintenance records for both powerplants, both propellers, and the airframe.[23]
Reactions
TransAsia Airways
Following the accident, TransAsia Airways changed its website and social media branding to greyscale images, in mourning for the presumed deaths of the passengers. On 5 February, TransAsia retired the flight number GE235, changing it to GE2353.[24]
Over half of the passengers on board the aircraft were Chinese. On 5 February 2015, Xi Jinping, the General Secretary of the Chinese Communist Party, released a statement, ordering that accurate information on the aircraft be obtained as quickly as possible, and that "assistance [be provided] in treating the injured".[27] On the same day, Chinese Premier Li Keqiang instructed relevant departments to obtain accurate information from Taipei as quickly as possible.[28]
Investigation
The Taiwanese Aviation Safety Council (ASC) led the investigation into the accident.[7][29] The French Bureau of Enquiry and Analysis for Civil Aviation Safety (BEA) represented the country of manufacture, and the Transportation Safety Board of Canada represented the country of engine manufacture. Other parties to the investigation included the Taiwanese Civil Aeronautics Administration, the operator (TransAsia), the aircraft (ATR) and engine (Pratt & Whitney Canada) manufacturers, and Transport Canada.[4]: v [30] The cockpit voice recorder and flight data recorder were recovered on the evening of 4 February, and the data were analysed.[5] According to the executive director of the ASC, Thomas Wang, the aircraft's right engine triggered an alarm just 37 seconds after takeoff.[31] Whereas the crew reported a flameout,[32] according to Wang, data showed the right engine had in fact been moved to idle power.[31] Soon the right engine failed to produce enough thrust for its rotating propeller, lapsing into auto-feathering.[32] A restart was attempted, but the aircraft crashed 72 seconds later.[31]
On 6 February, investigators revealed that the left engine, which does not appear to have had suffered a malfunction, had been manually shut off,[33] while cautioning that the investigation was "too early to say if human error was a factor".[34] Investigators released the following preliminary sequence of events:[4][30][35][36]
The ASC issued an interim report on 2 July. Without assigning responsibility for the crash, the report confirmed that a still-functional engine number one was incorrectly shut down by the pilot following the failure of engine number two (right engine).[1][2] The report also stated that the pilot in command had failed to pass a simulator test in May 2014, partly because he demonstrated insufficient knowledge about the procedure for handling an engine flameout during takeoff. He retook the test the following month, however, and successfully passed. The ASC released a draft report in November 2015 and published the final version in July 2016.[1][2][4]
The final report found that, following the uncommanded autofeather of engine number 2 (right engine), the pilot flying the aircraft reduced power and subsequently shut down the operative engine number 1 (left engine). The flight crew failed to perform the failure identification procedure and did not comply with standard operating procedures. As a result, the pilot flying the aircraft became confused regarding the identification and nature of the propulsion-system malfunction. The autofeathering was caused by compromised soldering joints in the autofeather unit. During the initial stages of the take-off roll, the flight crew did not reject the take-off when the automatic take-off power control system ARM pushbutton did not light, and TransAsia did not have a clear requirement to do so. The loss of engine power during the initial climb and inappropriate flight control inputs by the pilot flying generated stall warnings and activation of the stick pusher to which the crew did not respond in a timely and effective manner. The loss of power from both engines was not detected and corrected by the crew in time and the aircraft stalled during the attempted restart at an altitude from which they could not recover. Ineffective flight crew coordination, communication, and threat and error management compromised the safety of the flight. The crew failed to obtain relevant data from each other regarding the status of both engines. The pilot flying did not appropriately respond to input from the pilot monitoring.[4]
During the investigation, TransAsia Airways disclosed confidential information from the draft report to Next magazine, which published a story in its issue of 11 May 2016. This was an attempt to influence the investigation into the accident. TransAsia Airways were fined NT$3,000,000 (US$92,000).[37]
Aftermath
The Civil Aeronautics Administration announced it would subject all TransAsia Airways ATR pilots to supplementary proficiency tests between 7 and 10 February,[5] resulting in the cancellation of more than 100 TransAsia flights. Ten pilots who failed the engine-out oral test and a further nineteen who did not attend were suspended for one month, pending a retest. TransAsia subsequently demoted one pilot from captain to first officer.[1] Reuters reported that the government ordered all Taiwanese airlines to "review their safety protocols".[38][39] The Taiwanese CAA announced that it is focusing its attention on TransAsia's training and operations and the country's labor ministry fined the airline for breaches of the labor code over excessive working hours.[40][41]
On 11 February, TransAsia offered NT$14.9 million (about US$475,000) in compensation to the family of each of the dead. This amount includes emergency relief and funeral allowance, totaling NT$1.4M (US$44,300), already paid to each family. Not all of the families have accepted the offer.[42]
The taxi that was struck by the plane has been transported and preserved in the Taxi Museum in Su'ao, Yilan County.[43][44]
These two accidents significantly weakened the airline's image. The airline ceased operations and shut down indefinitely on 22 November 2016.[45]
In popular culture
The Canadian TV series Mayday (also known as Air Disasters and Air Emergency in the US and Air Crash Investigation in the UK and the rest of the world) covered Flight 235 in episode seven of season 17, called "Caught on Tape", which was first broadcast on 19 September 2017 in Australia.[46][47]
^The autofeather unit is supposed to cut in automatically so as to minimize the drag from a windmilling propeller in the event of a single engine failure.[4]: 79
^The First officer had dual New Zealand-Taiwanese citizenship
^复兴空难已救出20名伤者 3名无生命迹象 [Disaster recovery have been rescued 20 persons who have been injured 3 no sign of life]. sina.com.cn (in Chinese). Retrieved 4 February 2015.
^"復興航空說明 2015-02-04 2300版" [TransAsia Airways Public Statement 2015-02-04 2300 Edition]. tna.com.tw. 4 February 2015. Archived from the original on 7 February 2015. Retrieved 5 February 2015.
^ETtoday 新聞雲 (4 February 2015). "快訊／復興墜南港 馬英九指示全力搜救、全面援助" [News / Revival of South Port Ma Ying-jeou instructed full search and rescue, comprehensive assistance] (in Chinese). ETtoday 新聞雲. Retrieved 4 February 2015.
^Government of China (4 February 2015). 李克強就台灣復興航空班機墜河作出重要批示 [Li Keqiang made important instructions on the Taiwanese renaissance flight] (in Chinese). Government of China. Retrieved 4 February 2015.
^復興航空GE235飛航事故調查: 進度報告 [TransAsia Airways Flight GE 235 Accident Investigation Progress Report] (PDF). Aviation Safety Council (in Chinese). 6 February 2015. Retrieved 8 February 2015.
^"全球唯一計程車博物館 藏復興空難被撞小黃 李濟成 熱血擲6000萬 只為讓台灣更美好" [The only taxi museum in the world. Li Jicheng spent 60 million to make Taiwan a better place.]. Apple News Network (in Chinese (Taiwan)). 15 February 2020. Archived from the original on 29 April 2022.
