MQ-25 Stingray
MQ-25 refuels F-35C (cropped).jpg
MQ-25 Stingray during testing
Role Unmanned combat aerial vehicle for aerial refueling
National origin United States
Manufacturer Boeing
First flight 19 September 2019
Status In development
Primary user United States Navy

The Boeing MQ-25 Stingray is an aerial refueling drone that resulted from the Carrier-Based Aerial-Refueling System (CBARS) program, which grew out of the earlier Unmanned Carrier-Launched Airborne Surveillance and Strike (UCLASS) program. The MQ-25 first flew on 19 September 2019.

Development

Background

Main article: Unmanned Carrier-Launched Airborne Surveillance and Strike

The United States Navy began its efforts to develop an aircraft carrier-based UAV in 2006. The original UCLASS concept was for a stealthy strike platform capable of penetrating enemy air defenses. In 2012, lethality and strike requirements were diluted in order to create an intelligence, surveillance and reconnaissance (ISR)-oriented aircraft that could be developed quickly to conduct low-intensity counter-terrorism missions.[1]

On 1 February 2016, after delays over whether the UCLASS would specialize in strike or ISR roles, it was reported that significant priority would be given to producing a Super Hornet-sized carrier-based aerial refueling tanker as the Carrier-Based Aerial-Refueling System (CBARS), with "a little ISR" and some capabilities for communications relay, and strike capabilities put off to a future variant.[2] The Pentagon apparently made this program change to address the Navy's expected fighter shortfall by directing funds to buy more F/A-18E/F Super Hornets and accelerate purchases of the F-35C. Having the CBARS as the first carrier-based UAV provides a less complex bridge to the future F/A-XX, should it be an unmanned strike platform. It also addresses the carriers' need for an organic refueling aircraft, proposed for the UCLASS since 2014, freeing up the 20–30 percent of Super Hornets performing the mission in a more capable and cost effective manner than modifying the F-35, V-22 Osprey, and E-2D Hawkeye, or returning the retired S-3 Viking to service.[2][3][4]

Four development contracts were issued in 2016, with a formal RFP expected in 2017, with operational status in the early to mid-2020s.[5][6] In July 2016, it was officially named "MQ-25A Stingray" after being named RAQ-25A previously.[7]

Rear Adm. Michael Manazir has suggested that three of these UCAVs could fly with an F-35 for refueling and sensor operation.[8] Vice Adm. Mike Shoemaker said that the MQ-25 can extend the Super Hornet's 450 nmi (520 mi; 830 km) unrefueled combat radius to beyond 700 nmi (810 mi; 1,300 km). The Navy's goal for the aircraft is to be able to deliver 15,000 lb (6,800 kg) of fuel total to 4 to 6 airplanes at a range of 500 nmi (580 mi; 930 km).[9] The Navy released the final MQ-25 Stingray request for proposals in October 2017 to Lockheed Martin, Boeing, Northrop Grumman, and General Atomics.[10]

Selection

Boeing secretly finished building its wing-body-tail in 2014 when the UCLASS program was paused, and revived it for the CBARS mission.[11] On 19 December 2017, Boeing unveiled its prototype aircraft entrant that incorporated lessons learned from the Boeing Phantom Ray flying wing and its other unmanned aerial systems.[12] Boeing's MQ-25 design is not new for the tanking mission, but Boeing says that was considered when designing it.[11]

General Atomics proposed their Sea Avenger concept which was enlarged from its Predator-C/Avenger for refueling,[13] while Lockheed Martin proposed their Sea Ghost concept based on the RQ-170 Sentinel.[14]

Northrop Grumman announced on 25 October 2017 that it was withdrawing its X-47B from the MQ-25 competition, saying the company would have been unable to execute the program under the terms of the service's request for proposals.[15] The company's departure signaled to some analysts that the Navy's requirements could favor wing-body-tail designs, not the flying wings thought to be proposed by Northrop Grumman and Lockheed Martin.[16]

MQ-25 deck handling demonstration, 2018
MQ-25 deck handling demonstration, 2018

On 30 August 2018, the U.S. Navy announced Boeing as the winner of the competition and awarded an $805 million development contract for four MQ-25A aircraft to be completed by August 2024.[1] An additional three test MQ-25As were ordered on 2 April 2020 for a current total order of seven.[17] The program may expand to $13 billion overall and consist of 72 aircraft.[18]

Flight testing

MQ-25 T1 Stingray test aircraft refuels F-35C, 2021
MQ-25 T1 Stingray test aircraft refuels F-35C, 2021

In late April 2019, the first MQ-25 test aircraft (T-1 or "Tail 1") was taken by road from Boeing's technical plant at St. Louis's Lambert International Airport across the Mississippi River to MidAmerica St. Louis Airport, which is conjoined to Scott Air Force Base.[19] Following taxi tests, the Federal Aviation Administration certified the aircraft and granted airspace for flight testing. The MQ-25 took its first flight on 19 September 2019.[20]

In December 2020, Boeing released video showing the first flight of the MQ-25 with a Cobham aerial refueling store externally mounted.[21]

MQ-25 T1 Stingray test aircraft takes off, 2021
MQ-25 T1 Stingray test aircraft takes off, 2021

On 4 June 2021, the first refueling test was conducted, with the MQ-25 providing fuel to an F/A-18F Super Hornet. The MQ-25 originated at MidAmerica Airport in Mascoutah, Illinois, with support by Air Test and Evaluation Squadron VX-23. The mission lasted about 4.5 hours with the two aircraft performing numerous dry or wet connects for more than 10 minutes and 325 pounds of fuel transferred in total.[22] Further refueling tests were performed with E-2 and F-35C.[23]

Design

Boeing's MQ-25 design is powered by one Rolls-Royce AE 3007N turbofan engine delivering 10,000 lbf (44 kN) of thrust; this is a variant of the engine used to power the Navy's MQ-4C Triton.[24] The aircraft is less stealthy than flying wing UAVs. It does feature a stealthy fuselage shaping, flush inlet to shield engine blades from radar and V-tail.

Operational history

As of 2020 the United States Navy planned to establish Unmanned Carrier Launched Multi-Role Squadron 10 (VUQ-10) in October 2021 with four aircraft. The new unit was to be based at Naval Base Ventura County (which includes Naval Air Station Point Mugu).[25][26][27]

Operators

United States United States

Specifications (MQ-25A)

Data from NAVAIR[29] and USN MQ-25A Basing Draft Environmental Assessment[30]

General characteristics

Performance

Armament

See also

Aircraft of comparable role, configuration, and era

Related lists

References

  1. ^ a b LaGrone, Sam (August 30, 2018). "Navy Picks Boeing to Build MQ-25A Stingray Carrier-Based Drone". United States Naval Institute. Retrieved August 30, 2018.
  2. ^ a b Good-Bye, UCLASS; Hello, Unmanned Tanker, More F-35Cs In 2017 Budget - Breakingdefense.com, 1 February 2016
  3. ^ US Navy's Unmanned Jet Could Be a Tanker[permanent dead link] Defensenews.com, 1 February 2016
  4. ^ Pentagon to Navy: Convert UCLASS Program Into Unmanned Aerial Tanker, Accelerate F-35 Development, Buy More Super Hornets News.USNI.org, 1 February 2016
  5. ^ Osborn, Kris (24 October 2016). "Navy awards MQ-25 Stingray tanker deal". defensesystems.com. Defense Systems. Retrieved 22 December 2016.
  6. ^ Trimble, Stephen (20 October 2016). "USN awards MQ-25 risk reduction contract to Northrop Grumman". Flightglobal.com. RBI. Retrieved 25 October 2016.
  7. ^ LaGrone, Sam (15 July 2016). "It's Official: 'MQ-25A Stingray' U.S. Navy's Name For First Carrier UAV". news.usni.org. news.usni.org. Retrieved 18 July 2016.
  8. ^ Whittle, Richard (22 March 2016). "Navy Refueling Drone May Tie Into F-35s". breakingdefense.com. Breaking Media, Inc. Retrieved 23 March 2016.
  9. ^ "MQ-25 Stingray Unmanned Aerial Tanker Could Almost Double Strike Range of U.S. Carrier Air Wing" - News.USNI.org, 31 August 2017.
  10. ^ "Navy Releases Final MQ-25 Stingray RFP; General Atomics Bid Revealed" - News.USNI.org, 10 October 2017.
  11. ^ a b Rogoway, Tyler (13 March 2018). "We Finally See The Wings On Boeing's MQ-25 Drone As Details About Its Genesis Emerge". The Drive. Retrieved 31 May 2020.
  12. ^ Insinna, Valerie (December 20, 2017). "Boeing offers sneak peek of MQ-25 tanker drone". Defense News. So far, Boeing has released one photo of the aircraft facing head-on to the camera, proving that the company has fabricated a prototype and that — as expected — it has moved away from the flying wing design it considered putting forward to the precursor of the MQ-25 program, when the Navy prioritized strike and ISR capabilities for its first carrier-based drone.
  13. ^ Trevithick, Joseph (December 20, 2017). "General Atomics is the first to show of its MQ-25 tanker drone". The Drive.
  14. ^ Insinna, Valerie (December 20, 2017). "Lockheed reveals Sea Ghost concept for USN UCLASS programme". Defense News.
  15. ^ "Northrop Grumman pulls out of MQ-25 competition". FlightGlobal. 25 October 2017. Retrieved 26 October 2017.
  16. ^ Insinna, Valerie (December 20, 2017). "Boeing offers sneak peek of MQ-25 tanker drone". Defense News. So far, Boeing has released one photo of the aircraft facing head-on to the camera, proving that the company has fabricated a prototype and that — as expected — it has moved away from the flying wing design it considered putting forward to the precursor of the MQ-25 program, when the Navy prioritized strike and ISR capabilities for its first carrier-based drone.
  17. ^ David Donald (7 April 2020) Navy Orders More Test Stingrays from Boeing
  18. ^ Larter, Valerie Insinna, David (2018-08-30). "US Navy selects builder for new MQ-25 Stingray aerial refueling drone". Defense News. Retrieved 2018-08-30.
  19. ^ Cone, Allen."Boeing's MQ-25 refueling drone moved to air base for flight testing", SpaceDaily.com, 2019-05-01
  20. ^ D'Urso, Stefano (2019-09-20). "Boeing MQ-25 Stingray Carrier-Based Aerial Refueling Drone flies for the first time". The Aviationist. Retrieved 2019-09-22.
  21. ^ Sampson, Ben (17 December 2020). "Boeing MQ-25 aerial refueler makes first test flight with fuel store". Aerospace Testing International. Retrieved 7 January 2021.
  22. ^ Eckstein, Megan. "US Navy, Boeing conduct first-ever aerial refueling with unmanned tanker". Defence News, 7 June 2021.
  23. ^ Tyrrell, Michael (14 September 2021). "F-35 fighter refuelled in-flight by unmanned Boeing test aircraft - Aerospace Manufacturing". aero-mag.com.
  24. ^ Rolls-Royce to power Boeing MQ-25 Stingray Tanker Drone for US Navy. Navy Recognition. 15 September 2018.
  25. ^ Trevithick, Joseph (October 2020). "Navy Establishes First Squadron To Operate Its Carrier-Based MQ-25 Stingray Tanker Drones". The Drive. Retrieved 19 December 2021.
  26. ^ Burgess, Richard R.; Editor, Senior (2 August 2021). "Navy to Stand-Up 2 Fleet MQ-25 Squadrons to Deploy Detachments". Seapower. Retrieved 19 December 2021. ((cite web)): |last2= has generic name (help)
  27. ^ Burgess, Richard R. (2 October 2020). "Navy to Establish First MQ-25 Stingray UAV Squadron in 2021". seapowermagazine.org. Seapower. Retrieved 8 October 2020. and https://www.secnav.navy.mil/doni/Directives/05000%20General%20Management%20Security%20and%20Safety%20Services/05-400%20Organization%20and%20Functional%20Support%20Services/5400.2288%20(20).pdf (20 August 2020)
  28. ^ "Two Stingray MQ-25 fleet squadrons to be established".
  29. ^ "MQ-25™ Stingray". NAVAIR. Retrieved 20 Sep 2021.
  30. ^ "Home Basing of the MQ-25A Stingray Carrier-based Unmanned Air System" (PDF). US Department of Defense. Retrieved 22 March 2021.
  31. ^ "Rolls-Royce to power Boeing MQ-25 aircraft for US Navy". Rolls-Royce. Retrieved 22 March 2021.
  32. ^ "Selected Acquisition Report" (PDF). Washington Headquarters Services. Retrieved 20 Sep 2021.
  33. ^ Reim, Garrett. "Boeing flies MQ-25 with aerial refuelling pod for first time". Flight Global. DVV Media International Ltd. Retrieved 22 March 2021.

Media related to Boeing MQ-25 at Wikimedia Commons